We're thinking of ripping out our carpeting and replacing it with wood laminate flooring, probably the Harmonics brand that Costco is carrying. Has anyone here done this, and if so how did it go? Any tips on what to do, and what not to do?
Announcement
Collapse
No announcement yet.
Wood laminate floors
Collapse
X
-
Re: Wood laminate floors
I don't know about installation of hardwood floors, but I'll give some advice on what not to do when you use them:
- Don't drop any liquids on the floors
If you do, then clean it up right away, or the wood will crack, then replacement will be a pain.
- After the installation, clean it by sections, and stain it to protect it.
Consult someone at the hardware stores to see what kind of protection you should put.
When my family ripped out our ceramic tiles to expose the koa wood floor, that process took 1 week (removing the tiles, cleaning the floor, staining, and repeating that process for the 3 sections we had to do.How'd I get so white and nerdy?
-
Re: Wood laminate floors
I just recently helped a friend install the same Costco stuff in her son's bedroom. It was a lot easier than when I did Pergo (glue-type) in my house because you don't need to use those strap clamps and it's snap in. I believe the underlayment and the necessary tools and spacers were included as a separate kit. You'll still need a saw and hammer. Also, I believe there is a warranty regarding spills so long you install it per instructions.
The system is very user friendly as opposed to the Pergo installation. Even the underlayment was self-adhesive (no taping together required) and is already moisture-proof. Whereas in the case of Pergo brand you had to ante up more for a moisture-proof barrier. We ran out of underlayment but she was able to get more at Lowes or Home Depot.
Good luck!
Comment
-
Re: Wood laminate floors
We did our living room over the weekend and it went pretty well for us neophyte fixer-uppers.
Ripping up the old carpet was fun. Prying up all the carpet tack strips, and pulling out all the old nails and staples, was a tedious pain in the back (literally -- ouch). But getting down to a clean, unfinished floor was really satisfying.
Laying the underfloor was fairly straightforward. Laying the planks together was a snap (pun intended), at least most of the time. Some batches weren't quite as finely fitted as others, and needed extra encouragement (i.e. judicious tapping with a hammer) to fit properly.
The tricky part was doing the corners and the parts near doorways, which meant using a contour gauge to get the exact outline of the corner/molding/whatever, and doing some careful measuring and cutting to get the planks to fit.
We didn't bother with getting the special-order moldings from Harmonics (they have a 888 ordering number on the side of the installation kit box). We decided that having to make a special order, and waiting for delivery, was more trouble than it was worth. We just went to Lowe's and got moldings from another brand instead.
We're not quite done. The very last row of planks is going to have to be a skinny row (gotta cut all the planks lengthwise, a real chore since we don't have a table saw) but it should be OK. And we haven't installed skirting boards and moldings and stuff yet. But overall it was a lot smoother than I was afraid of.
Comment
-
Re: Wood laminate floors
Originally posted by adri1456When my family ripped out our ceramic tiles to expose the koa wood floor...
Comment
-
Re: Wood laminate floors
Originally posted by EricWe did our living room over the weekend and it went pretty well for us neophyte fixer-uppers.
I convinced my friend to go with 3" baseboard instead of the quarter-round. She painted it white to go with the rest of the trim in the house...looks really nice.
Were you able to take advantage of the $5 off per box deal that Costco had recently?
Comment
-
Re: Wood laminate floors
Originally posted by cezanneWere you able to take advantage of the $5 off per box deal that Costco had recently?
On the brighter side, it looks really nice and is a huge improvement over the ratty old carpet we used to have. Now the other rooms of the house look dingy by comparison.
Comment
-
Re: Wood laminate floors
Originally posted by cezanneWow I just reread your post! I don't think I could bear to watch someone putting that ceramic tile over a koa wood floor!
As we got older, we cracked the ceramic tiles enough to remove it and replace it, so we just replaced it all.
The only bad thing about koa wood, is that when we use the pledge spray to clean the floor, its very slippery, and with socks on (during the cold winter months) injuries went up the roof (figuratively, not literally).How'd I get so white and nerdy?
Comment
-
Re: Wood laminate floors
We finally finished laying floor in the living room. Here are some tips for anyone else who wants to do this kind of project -- probably obvious to the pros, but they were new to me:
- Fitting the planks together is best done as a two-person job. One person uses the hammer and tapping block, and the other keeps an eye on the joint to make sure that it's closing properly. If you try to do both yourself, you'll end up whacking the hammer into your fingers because you're too busy watching the other end of the plank.
- Be really careful with the edges of the planks, because that's where all those finely engineered tongue-and-groove bits are. If you damage the edge, then the plank is ruined and you can only use it by cutting the damaged portion off and using it as a start or end piece.
- Don't assume that anything in your house is actually straight, or level, or that corners are actually at right angles. They never are. Measure, measure, measure!
Comment
- Fitting the planks together is best done as a two-person job. One person uses the hammer and tapping block, and the other keeps an eye on the joint to make sure that it's closing properly. If you try to do both yourself, you'll end up whacking the hammer into your fingers because you're too busy watching the other end of the plank.
-
Re: Wood laminate floors
Originally posted by Eric[*]Don't assume that anything in your house is actually straight, or level, or that corners are actually at right angles. They never are. Measure, measure, measure![/list]How'd I get so white and nerdy?
Comment
-
Re: Wood laminate floors
Well, about a month has gone by since we laid our floor. So far so good, but I have noticed a couple of joints where the seams have opened up slightly -- less than a millimeter, but enough to be visible. I am not sure why this has happened. Expansion and contraction due to humidity changes, maybe? I'm also not sure how to make the gaps close up again - with all the planks installed, it's next to impossible to shift them around. Has anyone else experienced this, and if so, is it a big problem?
Comment
-
Re: Wood laminate floors
After putting the living room flooring in, we took a long break from home improvement work, but now it's time to think about doing the stairs too. Costco only sells the planks and installation kits for their brand, but after a bit of snooping I found that Costco's laminated flooring product is actually a rebranded version of Quick-Step's Uniclic flooring. They've got accessories like stair profiles, so you can install the stuff on stair steps.
They have a list of dealers who carry their products, and there are some in Hawai'i. I haven't checked any of them out yet, though. Does anyone know anything about these businesses?
HOMEOWNERS DESIGN CENTER
1030 Kohou Street #201 96817 Honolulu 808-847-0216 HI
ISLAND FLOORING CO, INC
500 Ala Kawa street #109 96817 Honolulu 808-847-6577 HI
PACIFIC RIM CPT & DRPRY LLC
PO Box 29241 96819 Honolulu 808-454-1154 HI
Floors of Hawaii
1312 Kaumualii Street Honolulu 808-845-9915 Hawaii
FLOOR STORE
1130 N. Nimitz Hwy. Ste. 153A Honolulu 808-547-2777 Hawaii
Abbey Carpet
98-761 Oihana Place Aiea 808-487-6667 Hawaii
FLOORING & HOME FASHIONS
96734 Kailua 808-262-7723 HI
KITCHEN CABINETS INC
73-4800 Kanalani st 96740 Kailua-Kona 808-329-5836 HI
Comment
-
Re: Wood laminate floors
Originally posted by EricWell, about a month has gone by since we laid our floor. So far so good, but I have noticed a couple of joints where the seams have opened up slightly -- less than a millimeter, but enough to be visible. I am not sure why this has happened. Expansion and contraction due to humidity changes, maybe? I'm also not sure how to make the gaps close up again - with all the planks installed, it's next to impossible to shift them around. Has anyone else experienced this, and if so, is it a big problem?
Comment
-
Re: Wood laminate floors
Originally posted by EricAfter putting the living room flooring in, we took a long break from home improvement work, but now it's time to think about doing the stairs too. Costco only sells the planks and installation kits for their brand, but after a bit of snooping I found that Costco's laminated flooring product is actually a rebranded version of Quick-Step's Uniclic flooring. They've got accessories like stair profiles, so you can install the stuff on stair steps.
They have a list of dealers who carry their products, and there are some in Hawai'i. I haven't checked any of them out yet, though. Does anyone know anything about these businesses? <snip>
Comment
-
Re: Wood laminate floors
Originally posted by cezanneAre the short joints opening? My friend had that happen to him. Luckily it was near the perimeter so he was able to use the metal tool that hooks to the edge of the flooring and hammer the joint closed. Only humbug part was having to remove the baseboard so that he can hook the edge.
Comment
Comment